Sign In
Sign-Up
Welcome!
Close
Would you like to make this site your homepage? It's fast and easy...
Yes, Please make this my home page!
No Thanks
Don't show this to me again.
Close
Maiden Flight Checklist
By: Peter Spink
RADIO
1. Gold sticker
2. Check frequency is clear
3. Battery charged
4. Trims neutral
5. Switch settings normal
INTERNAL
Servos
1. Secured in tray
2. Tray secured to fuselage
3. Screws & rubber grommets not too tight
4. Servo arm screws tight
5. Servo arm centered
Push rods
1. Ensure securely fastened
2. No bending, slop or binding
3. Quick connector retainers secure
4. Security ring on clevises
5. Check elevator, rudder & nose wheel throws & neutral position
Receiver
1. Battery charged
2. Electrical connections secure
3. Padded and secure
4. Battery padded and secure
5. Aerial routed straight and away from servos
6. Aerial strain relief
Tank
1. Foam wrapped
2. Secured from moving backwards in flight
3. Pressure pipe goes to top of tank
Engine
1. Securely mounted
2. Throws correct - idle and full
3. Propeller correct size
4. Propeller - sand edge
TAIL SECTION
1. Securely attached to fuselage
2. Tail wheel securely attached
WING
1. Warps or defects
2. Alignment & incidence with tail plane
3. Alignment with fin
4. Minimal gap between aileron & wing
5. Hinges secure but flexible
6. Aileron push rods, clevises & throws
7. Aileron neutral & throws
8. Number of elastic bands & replacement policy
FINAL CHECK
1. Check balance point C.G.
2. Check all flight controls for correct direction
3. Radio range check with antenna collapsed
4. Engine break-in
5. Engine adjust - high and low for smooth idle and transition to full throttle
6. Pre-flight check